Agronomy Talk

Agronomy Update

Ohio Field Observations: Fertilizer Burn

Published on Wednesday, June 8, 2016

A large percentage of Ohio’s corn acres were put in the ground over the last few weeks. Since then, the warm temperatures have caused corn to emerge rather quickly, in approximately five days vs. the April planted corn which, in some cases, took up to three weeks! As our customers are out scouting their fields, several of them have noticed a reduced stand and wondering what the causes might have been. They have seen plants similar to the photos below. 


Some plants don’t have much of a root system while others show a beautiful root system with no shoot. What is going on? In each case I have looked at this year, each farmer was using more than 30 lb. of total nitrogen (N) (28% plus 10-34-0) and/or sulfur in a 2x2 system. These reduced stands appear to be caused by fertilizer injury burn.  

Urea ammonium nitrate (28% UAN) is made up of 50 percent urea, 25 percent ammonium, and 25 percent nitrate. When urea volatilizes, it turns into ammonia (the same type of ammonia in anhydrous ammonia) and is lost to the air. That’s why we need to work in urea (or stabilize it) within a few days after application if we are using it as a N source. As a starter, stabilizing N is not recommended and is not normally a problem.

So what made urea volatilize faster this year?

  1. Volatility of urea is microbial driven, so warmer temperatures make this reaction occur more quickly. Urea can volatilize within two days in warmer temperatures. If the corn plant took up water slower (due to drying conditions, soil type, or planting depth), then the root system looks burned. If the plant took up water more quickly, then the root system developed and the coleoptile was burned off.

  2. Soils that are drying out cause the ammonia gas to move away from the 2x2 band, so moist soils followed by drying conditions cause more volatility. This is the same reason why anhydrous ammonia is injected 7 to 8 in. deep, because the ammonia gas will move up from the point of injection until it hits water. As the soil dries the ammonia will move up faster.

  3. Urea volatility is enhanced by higher pH. Unfortunately, the conditions that cause us to have higher yields can also increase volatility (both are due to enhanced microbial activity).

Higher rates of N in a 2x2 band has the potential to volatilize more anhydrous, thus causing more burn. This, along with higher temperatures and drying soils, is the reason why farmers who are applying higher rates of a starter may see more damage.

Comments (0)Number of views (17187)
Mark Apelt

Mark Apelt

Other posts by Mark Apelt
Contact author

Leave a comment

Add comment


Connect with us


Follow us on Pinterest Follow us on Pinterest